CH80 Speedometer not working?
Moderator: Moderator
CH80 Speedometer not working?
Hello all,
I verified the odometer cable is fine as I disconnected it and verified it moving as I am driving. I also hooked up another instrument cluster and the same thing, speedometer not moving. I thought maybe it's electronic, so I used the spare cluster and hooked up both odometer cable and wiring, same results.
Is this a known issue or is there a known fix?
Leo
I verified the odometer cable is fine as I disconnected it and verified it moving as I am driving. I also hooked up another instrument cluster and the same thing, speedometer not moving. I thought maybe it's electronic, so I used the spare cluster and hooked up both odometer cable and wiring, same results.
Is this a known issue or is there a known fix?
Leo
Re: CH80 Speedometer not working?
Did you check the plastic gear in the brake hub?
1986 Spree/ Eve af16 swapped 65cc Prodigy vari 8g 9:1 Ruima gears
21mm OKO 42/100 32:1 45mph kymco zx exhaust
1994 Elite S 17.5mm Arreche, Daytona reeds, SEF ramp, pump plugged
1987 Elite SE50 af16 swapped
1989 Elite E SB50p
2003 Yamaha Zuma
21mm OKO 42/100 32:1 45mph kymco zx exhaust
1994 Elite S 17.5mm Arreche, Daytona reeds, SEF ramp, pump plugged
1987 Elite SE50 af16 swapped
1989 Elite E SB50p
2003 Yamaha Zuma
Re: CH80 Speedometer not working?
If that was bad, I would assume the odometer cable wouldn't move, which it does.Mystic wrote:Did you check the plastic gear in the brake hub?
Re: CH80 Speedometer not working?
if plastic gear is not seating in place correctly it still moving and acting normal, but won't able to work with speedo.....do this test, un-tight brake cable 5-6 turns, spin the wheel, if the wheel is spinning freely then your installation was good, if the wheel spinning slowly then you might have had plastic gear incorrect installation.....after that you can use drill with a small (-) to test the speedo with cable connected........every time you install cable to wheel hub or to speedo the wheel should be spinning to have the best connections.MPDano wrote:If that was bad, I would assume the odometer cable wouldn't move, which it does.Mystic wrote:Did you check the plastic gear in the brake hub?
Kev
Re: CH80 Speedometer not working?
Plastic gear you speak of is in the front or rear wheel?kevinv710 wrote:if plastic gear is not seating in place correctly it still moving and acting normal, but won't able to work with speedo.....do this test, un-tight brake cable 5-6 turns, spin the wheel, if the wheel is spinning freely then your installation was good, if the wheel spinning slowly then you might have had plastic gear incorrect installation.....after that you can use drill with a small (-) to test the speedo with cable connected........every time you install cable to wheel hub or to speedo the wheel should be spinning to have the best connections.MPDano wrote:If that was bad, I would assume the odometer cable wouldn't move, which it does.Mystic wrote:Did you check the plastic gear in the brake hub?
Kev
Re: CH80 Speedometer not working?
Front wheel hub
1986 Spree/ Eve af16 swapped 65cc Prodigy vari 8g 9:1 Ruima gears
21mm OKO 42/100 32:1 45mph kymco zx exhaust
1994 Elite S 17.5mm Arreche, Daytona reeds, SEF ramp, pump plugged
1987 Elite SE50 af16 swapped
1989 Elite E SB50p
2003 Yamaha Zuma
21mm OKO 42/100 32:1 45mph kymco zx exhaust
1994 Elite S 17.5mm Arreche, Daytona reeds, SEF ramp, pump plugged
1987 Elite SE50 af16 swapped
1989 Elite E SB50p
2003 Yamaha Zuma
Re: CH80 Speedometer not working?
Ok, but with the odometer inner cable spinning as it should mean that plastic gear is working correctly, correct?Mystic wrote:Front wheel hub
Re: CH80 Speedometer not working?
Disregard guys. I just wasn't able to get it going fast enough around my pool for it to show on the speedo. Took it around the block a couple times and it works like a charm.
Thanks again!!
Thanks again!!
Re: CH80 Speedometer not working?
:facepalm:
RideRed
<Gyro S><MB5><Honda Navi><Helix><Sym Wolf><Yamaha Razz><Honda CH150 Deluxe>
"Live Large - Ride Small"
<Gyro S><MB5><Honda Navi><Helix><Sym Wolf><Yamaha Razz><Honda CH150 Deluxe>
"Live Large - Ride Small"
Re: CH80 Speedometer not working?
Hahaha good job. What up Mike how ya doin?
1986 Spree/ Eve af16 swapped 65cc Prodigy vari 8g 9:1 Ruima gears
21mm OKO 42/100 32:1 45mph kymco zx exhaust
1994 Elite S 17.5mm Arreche, Daytona reeds, SEF ramp, pump plugged
1987 Elite SE50 af16 swapped
1989 Elite E SB50p
2003 Yamaha Zuma
21mm OKO 42/100 32:1 45mph kymco zx exhaust
1994 Elite S 17.5mm Arreche, Daytona reeds, SEF ramp, pump plugged
1987 Elite SE50 af16 swapped
1989 Elite E SB50p
2003 Yamaha Zuma